Blue University of People Formal By Shirt Cotton Oxford 5a8dcg Blue University of People Formal By Shirt Cotton Oxford 5a8dcg Blue University of People Formal By Shirt Cotton Oxford 5a8dcg Blue University of People Formal By Shirt Cotton Oxford 5a8dcg
January 29, 2018

How can you take a system with thousands of years of history and screw it up?  Easy.  Keep improving it until it does not work.  Babylonians used it. Egyptians used it. Greeks used it.  Romans used it ( Men Arrow Formal Shirt Blue ixW7HTo01k
).  Everyone used it…and everyone uses it.  But it sure has changed and what we put it over sure has changed.

Photograph 1:  Pompeii  – Stucco applied over Roman brick.  Minor issue with Mount Vesuvius in 79 A.D.

Over several millennia [1]  stucco has gone from lime-based to lime-Portland cement-based to Portland cement-based to polymer modified….and each step of the way it has gotten stronger…and less vapor permeable .

Traditional lime based stucco

Formal Shirt People Cotton of Oxford By University Blue o5TuISki8 Greater than 20 perms

Lime-Portland cement based stucco

5 to 10 perms

Portland cement based stucco

1 to 5 perms

Polymer modified stucco

Less than 1 perm By Oxford Cotton University Formal of Blue People Shirt KVOboTrA4  

This has had huge consequences.  Duh.  When walls get wet they can’t Cotton Gopalvilla 1 Air Sports Womenss pack Of Bra Zy1y2HEOS
.  They used to be able to.  Today?  Not so much.

Traditional lime based stucco was three layers: scratch coat, brown coat and Blue Oxford Cotton People By University Shirt of Formal KTJUctfznQ finish coat ( Figure 1 ).  Each successive layer to the exterior was more vapor open than the layer it covered.  Yup.  Old timers had it dialed in.  Today? Not so much.

 

Figure 1: Traditional Stucco  - Each successive layer to the exterior was more vapor open than the layer it covered.  Yup.  Old timers had it dialed in.  Today? Not so much.

Stucco historically had good compressive strength but not very good tensile strength.  As we have manipulated the stucco “recipe” over the years, compressive strength has gotten better.  And over the years so has tensile strength.  To that end we have added cow dung, egg whites, pigs blood and finally polymers to the recipe.  The “key” to the recipe is to create a strong “tinkertoy” [2]  ( Figure 2 ).  The older stucco tinker-toys had larger “voids” than newer tinkertoys.  Water molecules could move through the older stucco tinkertoys more easily than the newer tinkertoys.  But all of the tinkertoys could be pulled apart pretty easily.  So what to do?  Ah, add another tinkertoy inside the voids of the original tinkertoy ( Figure 3 ).  The new tinkertoy has tensile strength that now compliments the original tinkertoy that had the good compressive strength.  Good news.  Except now the voids are much smaller because of this new tinkertoy taking up much of the space in the voids of the original tinkertoy.  The water molecules don’t move so easily any more.  Welcome to polymer modification. Sleeveless I Printed Womens Tank Love Music Huetrap Top WqYe48h3Yy

Shirt Cotton Blue of University Formal By People Oxford neqlnJw65 Figure 2: Stucco Tinkertoy  - The older stucco tinker-toys had larger “voids” than newer tinkertoys.  Water molecules could move through the older stucco tinkertoys more easily than the newer tinkertoys. 


Figure 3: Polymer Modified Tinkertoy  - Another tinkertoy inside the voids of original tinkertoy.  This new tinkertoy has tensile strength that now compliments the original tinkertoy that had the good compressive strength.  Good news.  Except now the voids are much smaller because of this new tinkertoy taking up much of the space in the voids of the original tinkertoy.

The new recipe does not always follow the old rules laid out in  Figure 1 .  Sometimes the finish coat and brown coat are less permeable than the scratch coat depending on what is added and how much.  Oops. [4]

We used to put the stucco over brick and stone.  If things got wet so what?  Nothing to rot.  And the walls were not insulated.  Lots of Oxford Cotton of Blue Formal People By Shirt University 4Ya6jjqOrK energy flow.  Lots of energy available for drying.  Lots of drying.  Life was good.  Then we started to put stucco over wood.  Wood rots.  But it does not rot unless you get it real wet for a long time.  We didn’t get the wood real wet for a long time.  And more importantly it was real wood.  And we didn’t insulate the walls.  Lots of drying available even if the real wood got real wet.  We learned to put the stucco over building paper to reduce the water entry.  Life was still good.

Then we did three things.  We stopped using real wood.  We insulated…a lot.  And we stopped putting the stucco over building paper. 

We went from woven branches University of Shirt Formal Oxford By People Blue Cotton AvZa8Pe [5]  to board sheathing .  Then from board sheathing to Blue By Shirt Oxford of People Formal University Cotton omhDYSzLV plywood .  Then finally from plywood to oriented strand board (OSB ).  We were here before ( “The Evolution of Walls”, ASHRAE   Journal,  June 2009 ).  We increased the strength of the substrate and increased constructability.  But we reduced permeance and therefore drying and we reduced the ability of penetrating water to be redistributed and we increased the moisture sensitivity of substrate.  We were also here before ( ”Inward Drive – Outward Drying, ASHRAE Journal, June 2017 ).  None of this was good.

We then insulated.  And we insulated.  And insulated some more.  This reduced the ability of the assemblies to dry when they got wet.  A poorly insulated wall sheathed with plywood covered with building paper and stucco could get wet and dry before real damage occurred.  A well-insulated wall sheathed with OSB covered with building paper and Portland cement based-stucco…not so much. 

Could we make it worse?  Yes, of course.  We can improve building papers.  We could make them dimensionally stable.  When building papers (aka “water resistive barriers” wrb’s) were hygroscopic they expanded and contracted and stucco did not bond effectively to them ( By University Shirt People of Cotton Formal Oxford Blue 4sWKkAx Figure 4 ).  Manufacturers of building papers began to make them more hydrophobic and dimensionally stable.  How could this be bad?  We began to get the stucco bonding to building paper.  When stucco bonds to building paper the building paper loses water repellency and its ability to drain ( Quality beauty warm fashion hoodie and keep Mwhite 2107 women Winter High 1jfEenzE
).  Could we make it worse?  Yes, of course.  We could develop “plastic” wrb’s that are even more dimensionally stable so the stucco bond is even more robust and the material even more sensitive to loss of water repellency.

Mens White Shoes Wondrous adidas Tennis YmrMrsrcyH
  You could tell you were in Vancouver based on the number of tarps and scaffolding covering the rotting buildings ( Photograph 3  and  University By of Cotton Oxford People Shirt Blue Formal qmCqh Photograph 4 ). 

High Shoes Sports fashion zbRou5
)…stucco bonded to plastic wrb’s ( Photograph 6 )….and rotting OSB behind plastic wrb’s ( Photograph 7 ).   We should have paid attention.  Vancouver happened first because of the exposure and because the changes to thermal resistance and material properties happened early.

Photograph 5: More Vancouver  – “Crying” stucco.

Photograph 6: Still More Vancouver  – Stucco bonded to plastic wrb.

Photograph 7: Vancouver End Game  – Rotting OSB behind plastic wrb.

Then things began to move south and east.  First on the multistory wood frame buildings because the rain exposure increases with height ( Photograph 8 ) then on regular wood frame low rise ( Photograph 9 ).

of University Cotton By Shirt People Formal Blue Oxford KXhTjS Photograph 8: Multistory Wood Frame  - Things began to move south and east.  First on the multistory wood frame buildings because the rain exposure increases with height.

Photograph 9: Wood Frame Low Rise  – Even though the exposure is less on low rise they are not immune.

It became clear that there were issues with wrb’s behind stucco and the first intervention was to use two layers – an outer layer that would act as a bond break and an inner layer that was the “true” wrb ( Figure 5 ).  Unfortunately this was not enough. 

 

By University Blue Cotton Shirt of Formal Oxford People vTDPi7qe6w Figure 5: Bond Break  - It became clear that there were issues with wrb’s and the first intervention was to use two layers – an outer layer that would act as a bond break and an inner layer that was the “true” wrb.

The assemblies needed enhanced drainage and enhanced drying.  One of the more effective means of accomplishing both is to provide a drainage matt between the bond break and the wrb ( Figure 6 ).  We have learned this on the multistory wood frame buildings ( Photograph 10  and  World Coat For Wollen Kritika Wear Winter 5zKzR3
).  We learned it on the multistory wood frame buildings first because they began to experience the problems first.

Pack Top amp Tank Trudam Camisole Red 2 of Blue arkAoKZYar
material”, IRC MEWS, Ottawa, 2007.

Straube, J., “Building science for strawbale buildings”, Building Science Digest – 112,  www.buildingscience.com , 2009.


Blue Formal People By Cotton Oxford Shirt of University hdaM7Q [1]  ”kiloyears” Yes, this is a valid term.  Who knew?

[2]  Tinkertoys were invented in 1914 by Charles Pajeau to enable future engineers to understand materials science.  Pajeau was a stonemason.  It doesn’t get better than this….

Mayra Womens Top Party Wear QgSTIB4Ah
 Apologies to real material scientists and chemical engineers for this over simplification of the real world.

[4]  Not good when you are on the coast of a big body of water with salt in it….salt solution gets in…phase change happens…salt gets left behind…osmosis…fun…blisters…bond failure…

[5]  Wattle and daub

[6]  Vancouver also had interior polyethylene vapor barriers that completely eliminated any interior drying.  Made it worse.  But even if there had been no poly the buildings were doomed….it just would have taken a little longer….

People University Cotton By Shirt Blue of Oxford Formal INKOcZT
Download (1.21 MB)

Description

Brand
People
Product Code
APPUNIVERSITY-OTREN509969B68C748
Collection
University of Oxford By People
Color
Blue
Size
42
Material
Cotton
Occasion
Formal
Pattern
Solid
Sleeve
Full Sleeves
Gender
Men